Holiday Rambler Endeavor Manual

What is wrong. REV Recreation Group (REV) is recalling certain 2022-2024 Fleetwood Discovery and Holiday Rambler Endeavor motorhomes, equipped with Remco 50-54 Rebel 4.0 GPM water pumps. The water pump harness was designed with inadequate fuse protection.

What can happen. Inadequate fuse protection may cause harness damage, increasing the risk of a fire.

The fix. Dealers will inspect and relocate the water pump circuit to a properly sized fuse as necessary, free of charge. Owner notification letters were mailed June 15, 2024. Owners may contact REV customer service at 1-800-509-3417. REV's number for this recall is 240416REV.

Campaign 24V279000. See it on NHTSA

What is wrong. REV Recreation Group (REV) is recalling certain 2023 Fleetwood Bounder, Flair, Flex, Fortis, Southwind, Discovery, Discovery LXE, Frontier, Frontier GTX, Pace Arrow, Holiday Rambler Admiral, Eclipse, Invicta, Vacationer, Armada, Endeavor, Navigator, Nautica, and American Coach American Tradition motorhomes. The entry door latch may fail and not allow entry or exit.

What can happen. The inability to enter or exit the vehicle in an emergency increases the risk of injury.

The fix. Dealers will inspect and if necessary, replace the door latch, free of charge. Owner notification letters were mailed May 12, 2023. Owners may contact Rev Customer Service at 1-800-509-3417. Rev's number for this recall is 230224REV.

Campaign 23V166000. See it on NHTSA

What is wrong. REV Recreation Group (REV) is recalling certain 2018-2019 Fleetwood Jamboree, 2020-2023 Fleetwood Southwind, Bounder, Flair, Fortis, Holiday Rambler Admiral, Invicta, Vacationer, 2021-2023 Fleetwood Discovery, Discovery LXE, Holiday Rambler Navigator, Armada, Nautica, 2023 Fleetwood Flex, Holiday Rambler Eclipse, 2021 Fleetwood Pace Arrow LXE, 2018 Holiday Rambler Vesta, 2022-2023 Fleetwood Frontier, 2021-2022 Fleetwood Pace Arrow, Holiday Rambler Endeavor, and 2019 Holiday Rambler Augusta motorhomes. The hydraulic lines may have been improperly routed, secured, or protected, which can result in a hydraulic fluid leak.

What can happen. A hydraulic fluid leak in the presence of an ignition source can increase the risk of a fire.

The fix. Dealers will inspect the hydraulic hoses for chafing or heat damage, and install hose protection, or replace them as necessary, free of charge. Owner notification letters were mailed October 28, 2022. Owners may contact REV customer service at 1-800-509-3417.

Campaign 22V655000. See it on NHTSA

How this part works is in our shore power and batteries manual.

What is wrong. REV Recreation Group (REV) is recalling certain 2021 Fleetwood Discovery, Discovery LXE, Pace Arrow, Pace Arrow LXE, Bounder, and Southwind and Holiday Rambler Armada, Endeavor, Nautica, Navigator, and Vacationer motorhomes. The primary gear of the bed lift motor may fail, allowing the bed frame to drop.

What can happen. A bed frame that drops can increase the risk of an injury.

The fix. REV will notify owners, and dealers will inspect, and if necessary, replace the bed lift motor, free of charge. The recall is expected to begin January 12, 2021. Owners may contact REV customer service at 1-800-509-3417. REV's number for this recall is 201109REV.

Campaign 20V706000. See it on NHTSA

What is wrong. REV Recreation Group (REV) is recalling certain 2020 Fleetwood Pace Arrow LXE, Discovery and Discovery LXE, and Holiday Rambler Navigator and Endeavor motorhomes. The wire harness/plumbing bundle within the slideout raceway may have been improperly wrapped and secured.

What can happen. Without the proper securement, the wire harness/plumbing bundle can become damaged, increasing the risk of a fire.

The fix. REV will notify owners, and dealers will inspect, repair, reroute and resecure the wire harness/plumbing bundle, free of charge. The recall began January 31, 2020. Owners may contact REV customer service at 1-800-509-3417. REV's number for this recall is 191126REV.

Campaign 19V861000. See it on NHTSA

How this part works is in our shore power and batteries manual.

What is wrong. REV Recreation Group (REV) is recalling certain 2018 Fleetwood Axon and Pulse, Holiday Rambler Reno and Prodigy, Monaco Marquis and American Coach American Dream motorhomes, 2017-2018 Fleetwood Bounder, Discovery, Discovery LXE, Flair, Jamboree, Southwind, Pace Arrow, Pace Arrow LXE and Storm motorhomes, Holiday Rambler Admiral XE, Endeavor, Endeavor XE, Navigator XE, Navigator, Vacationer, Vacationer XE and Vesta and American Coach American Eagle motorhomes and 2017 Holiday Rambler Scepter, Monaco Diplomat, and American Coach American Revolution motorhomes. The mounting screws for the satellite dish may not have been fastened through the sheet steel reinforcement, possibly allowing the satellite dish to detach from the roof while driving.

What can happen. If the satellite dish detaches from the roof while driving, it can increase the risk of a crash or injury.

The fix. REV will notify owners, and dealers will resecure the satellite dish to the roof with a metal reinforcement, free of charge. The recall began on May 14, 2018. Owners may contact REV customer service at 1-800-509-3417. REV's number for this recall is 180322REV. Note: This recall supersedes recall 17V-802. Any vehicle repaired under that campaigned is not included in this one as the remedy for both recalls is the same.

Campaign 18V202000. See it on NHTSA

What is wrong. REV Recreation Group (REV) is recalling certain 2018 American Coach American Dream and American Revolution motorhomes, Fleetwood Discovery, Discovery LXE, Pace Arrow and Pace Arrow LXE motorhomes, Holiday Rambler Endeavor, Endeavor XE, Navigator and Navigator XE motorhomes and Monaco Marquis and Signature motorhomes equipped with an Aurora heating, ventilation and air conditioning (HVAC) system. The wires for the HVAC system potentiometer may become disconnected from the quick connect terminals.

What can happen. If the potentiometer wires detach and are reconnected incorrectly, there is an increased risk of a fire.

The fix. REV will notify owners, and dealers will inspect the potentiometer and solder the wires or replace the control panel, if necessary, free of charge. The recall began on May 14, 2018. Owners may contact REV customer service at 1-800-509-3417. REV's number for this recall is 180315REV.

Campaign 18V183000. See it on NHTSA

How this part works is in our shore power and batteries manual.

What is wrong. REV Recreation Group (REV) is recalling certain 2018 American Coach American Dream, American Revolution, Fleetwood Discovery, Discovery LXE, Holiday Rambler Endeavor, Endeavor XE, and Monaco Marquis recreational vehicles. Water may enter the 12-volt harness connectors due to missing gaskets or the placement of the pin connectors, potentially causing an electrical short.

What can happen. An electrical short can increase the risk of a crash.

The fix. REV Recreation Group will notify owners, and dealers will inspect, and if necessary, install a gasket for each affected harness pin connector and re-route harnesses that terminate near luggage compartment number five, free of charge. The recall began on February 15, 2018. Owners may contact REV customer service at 1-800-509-3417. REV's number for this recall is 171213REV.

Campaign 17V829000. See it on NHTSA

How this part works is in our shore power and batteries manual.

What is wrong. REV Recreation Group (REV) is recalling certain 2009-2010 and 2012-2014 Holiday Rambler Ambassador, 2010 and 2013-2014 Endeavor, 2009-2010 Neptune, 2010 Scepter, and 2011 Trip diesel motorhomes, equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

What can happen. In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

The fix. REV will notify owners, and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall is expected to begin January 18, 2018. Owners may contact REV customer service at 1-800-509-3417, or Kidde customer service at 1-855-262-3540 or online at www.kidde.com and click on "Product Safety Recall" for more information.

Campaign 17V734000. See it on NHTSA

What is wrong. REV Recreation Group (REV) is recalling certain 2017-2018 Fleetwood Discovery and Discovery LXE, and Holiday Rambler Endeavor, Endeavor XE, and Admiral XE motorhomes, as well as 2018 Monaco Diplomat, Fleetwood Pace Arrow, Bounder, Flair, and Storm motorhomes, and Holiday Rambler Navigator and Vacationer XE motorhomes. The affected vehicles may have been manufactured with headlights that do not have tempered glass lenses.

What can happen. If the headlamp lens is not tempered, it may crack or break, which may cause decreased illumination and/or premature failure of the headlight bulb, increasing the risk of a crash.

The fix. REV Recreation Group will notify owners, and authorized REV dealers will inspect, and if necessary, replace non-tempered, defective headlamp lenses with new headlamp lenses, free of charge. The recall began on September 8, 2017. Owners may contact REV customer service at 1-800-509-3417. REVs number for the recall is 170720REV.

Campaign 17V477000. See it on NHTSA

What is wrong. REV Recreation Group (REV) is recalling certain model year 2016-2017 Holiday Rambler Endeavor motor homes, models 40DP, 40G, 40E, 40G and 40X, manufactured November 23, 2015, to April 7, 2016, and Holiday Rambler Endeavor XE motor homes , model 37PE, manufactured November 17, 2015, to April 6, 2016. The affected vehicles have a section of framework that may rub, or cause the mud flap to rub, against the front passenger-side tire, resulting in excessive tire wear. Additionally, steering may be restricted.

What can happen. Excessive tire wear may result in tire failure. Restricted steering can affect control of the vehicle. Either condition increases the risk of a crash.

The fix. REV will notify owners, and dealers will inspect the tube steel skirt framing and remove the diagonal section if present, and install additional screws to secure the mud flap. This repair will be done free of charge. The recall began on June 14, 2016. Owners may contact REV customer service at 1-800-509-3417. REV's number for this recall is 160429REV.

Campaign 16V278000. See it on NHTSA

How this part works is in our tires, wheels and bearings manual.

What is wrong. Allied Recreation Group, Inc. (ARG) is recalling certain model year 2010-2011 Holiday Rambler Admiral, 2009-2014 Holiday Rambler Ambassador, 2010 Holiday Rambler Arista, 2010-2014 Holiday Rambler Endeavor, 2009-2011 Holiday Rambler Neptune, 2011-2014 Holiday Rambler Vacationer, 2009-2011 Monaco Cayman, 2010-2014 Monaco Diplomat, 2014 Monaco Dynasty, 2009-2014 Monaco Knight, 2012-2013 Monaco LaPalma, 2009-2013 Monaco Monarch, 2009-2011 Monaco Riptide, 2008 Safari Passage, and 2008 Safari Simba motorhomes. The affected vehicles are equipped with certain Lippert-brand Coachstep Double Electric Steps. These steps use a bolt to attach the fan gear assembly to the steps. This bolt may fracture allowing the fan gear to disengage from the steps. As a result, the steps may not remain in the expected position and may be unstable.

What can happen. Unstable entry and exit steps increase the risk of injury.

The fix. ARG will notify owners and dealers will install a retainer bracket to reinforce the operating mechanism, free of charge. The recall began on February 12, 2016. Owners may contact ARG customer service number at 1-800-509-3417. ARG's number for this recall is 151216REV.

Campaign 15V872000. See it on NHTSA

What is wrong. Navistar is recalling certain model year 2012-2013 IC Bus brand model 1300FBC, CE, HC, and RE buses; model year 2011-2013 International brand model Durastar, model year 2013 International brand Workstar trucks; model year 2013 Holiday Rambler brand model Ambassador and Endeavor vehicles; and model year 2013 Monaco brand model Diplomat and Knight vehicles. These vehicles were manufactured August 5, 2010 through September 6, 2012 and are equipped with certain 2011-2013 model year I-6 engines with feature codes 12NUK, 12NUL, 12NUM, 12NUN, 12NUP, 12NUR, 12NUS, 12NUT, 12NUU, 12NUV, 12NUX, 12NUY and 12NUZ. The injection pressure regulator (IPR) harness wire may break due to vibrational damage. This could cause an unexpected shut down of the engine.

What can happen. An unexpected engine shut down while driving may increase the risk of a vehicle crash.

The fix. Navistar will notify owners, and dealers will replace the IPR wire connector free of charge. The safety recall began on March 15, 2013. Owners may contact Navistar at 1-800-448-7825.

Campaign 13V020000. See it on NHTSA

What is wrong. NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2008-2010 BEAVER AND CERTAIN MODEL YEAR 2009-2011 MONACO, AND CERTAIN MODEL YEAR 2009-2011 HOLIDAY RAMBLER RECREATIONAL VEHICLES, MANUFACTURED FROM OCTOBER 25, 2007, THROUGH AUGUST 26, 2010, EQUIPPED WITH IOTA ITS-50R 50 AMP AUTOMATIC TRANSFER SWITCHES. THE IOTA ITS-50R 50 AMP AUTOMATIC TRANSFER SWITCH BUS BAR AND/OR ELECTRICAL CONNECTIONS MAY BE INADEQUATE TO HANDLE THE ELECTRICAL LOAD.

What can happen. ELECTRICAL OVERLOAD OF THE TRANSFER SWITCH COULD LEAD TO OVERHEATING, AND A FIRE, INCREASING THE RISK OF PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.

The fix. NAVISTAR WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE IOTA ITS-50R TRANSFER SWITCH FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 15, 2012. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825.

Campaign 12V060000. See it on NHTSA

How this part works is in our shore power and batteries manual.

What is wrong. NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2009-2011 BEAVER, HOLIDAY RAMBLER AND MONACO COACH BRAND RECREATIONAL VEHICLES MANUFACTURED FROM JANUARY 11, 2008, THROUGH APRIL 15, 2011. SEE THE ABOVE LIST FOR MODELS. THE FRONT WINDSHIELD SHADE MAY SEPARATE FROM THE CABIN BODY WITHOUT WARNING, POSSIBLY IMPAIRING THE DRIVER'S ABILITY TO SEE THE ROADWAY.

What can happen. AN IMPAIRMENT TO A DRIVER'S ABILITY TO SEE THE ROADWAY COULD CAUSE A VEHICLE CRASH POTENTIALLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.

The fix. NAVISTAR WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE SHADE MOUNTING CLIPS AND REPAIR THE VEHICLES AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DECEMBER 10, 2011.OWNERS MAY CONTACT NAVISTAR AT 1-877-466-6226.

Campaign 11V557000. See it on NHTSA

What is wrong. NAVISTAR IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

What can happen. THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

The fix. NAVISTAR IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE SAFETY RECALL BEGAN ON DECEMBER 1, 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101.

Campaign 10V588000. See it on NHTSA

What is wrong. KONGSBERG POWER PRODUCTS SYSTEMS I, INC., (KPPS) IS RECALLING ON BEHALF OF MONACO COACH CERTAIN MODEL YEAR 2008-2010 MOTOR HOMES MANUFACTURED AFTER APRIL 2007 AND EQUIPPED WITH PNEUMATIC AND HYDRAULIC ADJUSTABLE BRAKE PEDAL ASSEMBLIES SUPPLIED BY KPPS. THE DRIVE PIN WHICH SECURES THE BRAKE PEDAL ARM TO THE BALANCE OF THE ASSEMBLY MAY BECOME DISENGAGED, THIS MAY CAUSE A REDUCTION IN VEHICLE BRAKING AND/OR CAUSE THE BRAKE PEDAL TO MOVE OUT OF POSITION AND INTERFERE WITH THROTTLE PEDAL FUNCTION.

What can happen. A REDUCTION IN BRAKING OR INTERFERENCE WITH THE THROTTLE PEDAL COULD RESULT IN A CRASH.

The fix. KPPS WILL PROVIDE A CLAMP ASSEMBLY KIT ALONG WITH INSTALLATION INSTRUCTIONS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 16, 2010. OWNERS MAY CONTACT KPPS AT 1-877-485-6647.

Campaign 10V284000. See it on NHTSA

What is wrong. NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2008-2009 BEAVER CONTESSA, MODEL YEAR 2009 BEAVER MARQUIS, PATRIOT, MONTEREY, MODEL YEAR 2009-2010 HOLIDAY RAMBLER AMBASSADOR, MODEL YEAR 2010-2011 HOLIDAY RAMBLER ENDEAVOR, MODEL YEAR 2009-2010 HOLIDAY RAMBLER IMPERIAL, MODEL YEAR 2010 HOLIDAY RAMBLER NAVIGATOR, AND SCEPTOR, MODEL YEAR 2010 MONACO CAMELOT MODEL YEAR 2010-2011 MONACO DIPLOMAT, MODEL YEAR 2010 MONACO DYNASTY, MODEL YEAR 2009-2010 MONACO KNIGHT AND MODEL YEAR 2010 MONACO SIGNATURE MANUFACTURED FROM JANUARY 22, 2008 THROUGH OCTOBER 27, 2009 ON BEHALF OF MONACO RV WITH KONGSBERG POWER PRODUCTS SYSTEMS ADJUSTABLE BRAKE PEDALS. THE DRIVE PIN WHICH SECURES THE BRAKE PEDAL ARM TO THE BALANCE OF THE ASSEMBLY MAY BECOME DISENGAGED, THIS MAY CAUSE A REDUCTION IN VEHICLE BRAKING AND/OR CAUSE THE BRAKE PEDAL TO MOVE OUT OF POSITION AND INTERFERE WITH THROTTLE PEDAL FUNCTION.

What can happen. A REDUCTION IN BRAKING OR INTERFERENCE WITH THE THROTTLE PEDAL COULD RESULT IN A VEHICLE CRASH.

The fix. NAVISTAR IS WORKING WITH KONGSBERG PLEASE SEE KONGSBERG DEFECT REPORT 09E-064. NAVISTAR WILL RECEIVE KITS AND WILL INSPECT AND INSTALL A C-CLAMP ON THE ADJUSTABLE BRAKE PEDAL. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 4, 2010. OWNERS MAY CONTACT NAVISTAR AT 1-800-685-6545.

Campaign 10V014000. See it on NHTSA

What is wrong. MONACO IS RECALLING 1,733 MY 2006-2007 DIPLOMAT AND HOLIDAY RAMBLER ENDEAVOR MOTOR HOMES EQUIPPED WITH WIPER SYSTEMS SUPPLIED BY AM EQUIPMENT. THE DRIVE MOTOR LINK BECOMES DISENGAGED DURING OPERATION FROM THE WIPER DRIVE ARM WHERE IT ATTACHES TO THE DRIVE ARM CAUSING THE WIPER SYSTEM TO FAIL.

What can happen. WHEN THE WIPER SYSTEM FAILS, THE OPERATOR WILL HAVE REDUCED VISIBILITY WHICH COULD RESULT IN A CRASH.

The fix. MONACO WILL REPLACE THE COMPLETE UNDER-THE-HOOD WIPER SYSTEM WITH A NEW MODEL, REUSING THE WIPER ARM AND BLADES. THE RECALL BEGAN ON MARCH 11, 2008. OWNERS MAY CONTACT MONACO AT 1-800-685-6545.

Campaign 08V070000. See it on NHTSA

What is wrong. ON CERTAIN MOTOR HOMES EQUIPPED WITH ATWOOD SEALED BURNER RANGES, THE RANGE AND SLIDE-IN BURNER TUBES LEADING FROM THE GAS MANIFOLD TO THE BURNER HEADS HAD A DEPRESSION OR 'KINK' IN THE EXTERIOR BEND RESTRICTING PROPER AIRFLOW AND GAS MIXTURE.

What can happen. THIS CONDITION COULD RESULT IN CARBON MONOXIDE POISONING.

The fix. MONACO IS WORKING WITH ATWOOD TO HAVE THE TUBES REPLACED ON THESE RANGES. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS MAY CONTACT ATWOOD AT 1-800-348-7418 OR MONACO AT 1-800-685-6545.

Campaign 07V404000. See it on NHTSA

What is wrong. ON CERTAIN MOTOR HOMES BUILT WITH CUMMINS ISL CM850 DIESEL ENGINES, THE CONNECTING ROD CONTAINS A MACHINING DEFECT IN THE WRIST PIN BUSHING OF THE ROD THAT COULD CAUSE A SEIZURE OF THE PISTON PIN.

What can happen. IF ALLOWED TO PROGRESS, THIS CAN LEAD TO ENGINE FAILURE WITH THE POSSIBILITY OF THE ROD RUPTURING THE LOCK CAVITY, OIL AND DEBRIS ON THE ROADWAY AND VEHICLE CRASH.

The fix. MONACO IS WORKING WITH CUMMINS TO RECALIBRATE THE ENGINE CONTROL MODULE AND ENHANCE THE ENGINE PROTECTION SYSTEM ENABLING IT TO PROVIDE EARLY DETECTION OF THE FAILURE MODE AND AVOID MORE SERIOUS ENGINE DAMAGE AND RESULTANT SAFETY HAZARD. CUMMINS WILL ALSO INSTALL A NEW VALVE COVER WITH A CRANKCASE PRESSURE SENSOR FREE OF CHARGE (PLEASE SEE 07E033). OWNERS MAY CONTACT CUMMINS AT 800-343-7357 OR MONACO AT 1-800-685-6545.

Campaign 07V311000. See it on NHTSA

What is wrong. ON CERTAIN CLASS A MOTOR H0MES BUILT WITH GASOLINE ENGINES, THE FRAME EXTENSION LOWER FLANGE MAY CRACK ALLOWING THE HITCH TO BEND AND POSSIBLY SEPARATE FROM THE MOTOR HOME.

What can happen. THIS COULD RESULT IN SEPARATION OF THE TOWED VEHICLE.

The fix. DEALERS WILL ADD AN ADDITION OF TWO PIECES OF ANGLE STEEL TO THE FRAME EXTENSION AND HITCH MOUNTING POINT IN ORDER TO REINFORCE THE FRAME EXTENSION FLANGE FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 15, 2007. OWNERS MAY CONTACT MONACO AT 877-466-6226. NOTE: THE ENDING MANUFACTURING DATE FOR INDIANA BUILT MOTOR HOMES IS MARCH 8, 2002 WHILE THE OREGON BUILT MOTOR HOMES WERE BUILT THROUGH NOVEMBER 2002. THE FEDERAL ID LABEL LOCATED ON THE WALL NEXT TO THE DRIVER'S SEAT SPECIFIES IN WHICH STATE THE MOTOR HOME WAS BUILT.

Campaign 07V010000. See it on NHTSA

How this part works is in our hitching a trailer manual.

What is wrong. ON CERTAIN MOTOR HOMES, THE HEADLIGHT SWITCH IN THE FRONT ELECTRICAL BOX/FIREWALL CAN OVERLOAD.

What can happen. CHANGES IN THE COMPONENT SUPPLIER RELAY REQUIREMENTS WITH AN UPDATED CONTROLLER WERE CAUSING THE HEADLIGHTS TO STOP FUNCTIONING WITHOUT WARNING. THIS COULD POTENTIALLY CAUSE A CRASH WHILE DRIVING AT NIGHT.

The fix. DEALERS WILL INSTALL A NEW WIRING HARNESS. THE RECALL BEGAN ON SEPTEMBER 30, 2005. OWNERS MAY CONTACT MONACO AT 1-800-685-6545.

Campaign 05V366000. See it on NHTSA

What is wrong. ON CERTAIN MOTOR HOMES, THE WATER HEATER EXHAUST ON THE CURVE SIDE WALL UNDER THE BACK SIDE OF THE KITCHEN SLIDEOUT ROOM BOX TERMINATES UNDER THE SLIDE BOX WHEN IN THE EXTENDED POSITION. THIS DESIGN COULD CREATE A RISK OF MIGRATION OF CARBON MONOXIDE INTO THE INTERIOR OF THE MOTOR HOME.

What can happen. EXPOSURE OF THE OCCUPANTS TO CARBON MONOXIDE COULD RESULT IN INJURY OR DEATH.

The fix. DEALERS WILL REPLACE THE WATER HEATER WITH A 16 GALLON ATWOOD UNIT THAT HAS A DIFFERENT EXHAUST TERMINATION. THE RECALL BEGAN MARCH 25, 2005. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.

Campaign 04V598000. See it on NHTSA

How this part works is in our propane, furnace and fridge manual.

What is wrong. ON CERTAIN MOTORHOMES EQUIPPED WITH CUMMINS ENGINES, OIL CAN LEAK INTO THE ENGINE COMPARTMENT FROM A CRACK IN THE CUP PLUG.

What can happen. OIL LEAKAGE ON A HOT ENGINE CAN RESULT IN AN ENGINE COMPARTMENT FIRE, POSSIBLY RESULTING IN INJURIES.

The fix. CUMMINS IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. CUMMINS WILL INSTALL A STEEL CUP PLUG BOSS CAP TO ALL AFFECTED ENGINES. OWNERS SHOULD CONTACT CUMMINS CUSTOMER ASSISTANCE CENTER AT 1-800-343-7357 OR MONACO AT 1-800-685-6545.

Campaign 04V441000. See it on NHTSA

What is wrong. ON CERTAIN CLASS A MOTOR HOMES, A TYPOGRAPHICAL ERROR OCCURRED IN THE PRINTING OF THE FEDERAL CERTIFICATION LABEL. THE INITIAL LABEL SHOWS A FRONT PSI OF 105 FOR 255/70R22.5 SIZED TIRES WITH AN 11,000 LB FRONT AXLE. THE CORRECT PSI FOR 255/70R22.5 TIRES ON AN 11,000 LB FRONT AXLE SHOULD BE 115 PSI.

What can happen. THESE VEHICLES DO NOT COMPLY WITH THE REGULATIONS.

The fix. DEALERS WILL INSTALL A CORRECTED LABEL ON THESE MOTOR HOMES. OWNER NOTIFICATION BEGAN AUGUST 20, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE LABEL WITHIN A REASONABLE TIME SHOULD CONTACT MONACO AT 1-877-466-8226.

Campaign 03V104000. See it on NHTSA

What is wrong. CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.

What can happen. IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE BRAKE SYSTEM WARNING INDICATOR.

The fix. DEALERS WILL REPAIR THE BRAKE WARNING LAMP CIRCUIT. OWNER NOTIFICATION BEGAN MAY 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MONACO COACH AT 1-877-477-6226.

Campaign 03V068000. See it on NHTSA

What is wrong. ON CERTAIN CLASS A MOTOR HOMES, THE FLOOR TRUSS NETWORK SUPPORT SYSTEM HAS A POTENTIAL TO WEAKEN CAUSING INTERNAL AND EXTERNAL FEATURES TO BECOME MISALIGNED. THE AFFECTED VEHICLES ARE 1999 - 2003 CLASS A MOTOR HOMES MANUFACTURED ON F53 20,500 POUND GROSS VEHICLE WEIGHT RATING (GVWR), FORD CHASSIS, AND 2000-2003 CLASS A MOTOR HOMES MANUFACTURED ON W-22 22,000 POUND GVWR, WORKHORSE CHASSIS.

What can happen. CONDITIONS CAN RESULT IN THE BOTTOMING OUT THE SUSPENSION AND AMPLIFICATION OF THE STRESS PLACED ON THE FLOOR TRUSS NETWORK. THE ADDITIONAL STRESS CAN RESULT IN THE FRACTURE OF WELDS SECURING THE FLOOR TRUSS NETWORK SYSTEM TO THE CHASSIS FRAME RAIL AND/OR FRACTURE OF THE FLOOR TRUSS NETWORK SUPPORT SYSTEM. THE POSSIBILITY EXISTS THAT THERE COULD BE DAMAGE TO ELECTRICAL WIRING AND/OR FUEL LINES WHICH COULD POTENTIALLY LEAD TO A FIRE.

The fix. DEALERS WILL INSPECT THE FLOOR TRUSS NETWORK SUPPORT SYSTEM, REINFORCE THE EXISTING STRUCTURE, AND REPAIR, AS NEEDED, THE FLOOR TRUSS NETWORK SUPPORT. OWNER NOTIFICATION BEGAN NOVEMBER 5, 2002. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.

Campaign 02V237000. See it on NHTSA

What is wrong. ON CLASS A MOTOR HOMES BUILT WITH A STEERABLE AUXILIARY AXLE AND EQUIPPED WITH CERTAIN MERITOR-WABCO BRAKE SYSTEM TWO AND FOUR PORT RELAY VALVES, THE VALVE MAY STICK OPEN WHEN A HIGH-PRESSURE BRAKE APPLICATION IS RELEASED.

What can happen. WHEN THE VALVE STICKS OPEN, IT CAN RESULT IN A TOTAL LOSS OF AIR FROM EITHER THE SERVICE OR THE PARK BRAKE SYSTEM. THE DRIVER MAY LOSE BRAKING ABILITY UNDER A SERVICE APPLICATION, POSSIBLY RESULTING IN A VEHICLE CRASH.

The fix. DEALERS WILL REPLACE THESE VALVES. MERITOR WABCO IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MERITOR WABCO AT 800-535-5560 OR MONACO AT 1-877-466-6226.

Campaign 02V013001. See it on NHTSA

What is wrong. VEHICLE DESCRIPTION: CERTAIN CLASS A MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." FRONT REFLECTORS NEED TO BE INSTALLED ON THE SIDE OF THE FRONT CAP.

What can happen. THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

The fix. DEALERS WILL INSTALL A REFLECTOR ON EACH SIDE OF THE FRONT CAP. OWNER NOTIFICATION BEGAN DECEMBER 4, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MONACO AT 1-877-466-6226.

Campaign 01V360000. See it on NHTSA

What is wrong. VEHICLE DESCRIPTION: CLASS A MOTOR HOMES EQUIPPED WITH SAFETY BELT ASSEMBLIES BUILT BY AM-SAFE. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.

What can happen. SERIOUS INJURY OR DEATH COULD OCCUR IF THE VEHICLE OCCUPANT IS NOT PROPERLY RESTRAINED.

The fix. DEALERS WILL INSPECT THE LAP BELTS AND, IF NECESSARY, REPLACE IT WITH A NEW BELT ASSEMBLY. AM-SAFE IS CONDUCTING THE OWNER NOTIFICATION. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AM-SAFE AT 219-266-8330 OR MONACO AT 219-862-7211.

Campaign 01V128005. See it on NHTSA

What is wrong. VEHICLE DESCRIPTION: MOTOR COACHES PRODUCED ON ROADMASTER CHASSIS AND DIESEL CLASS A MOTOR COACHES PRODUCED ON FREIGHTLINER CHASSIS. THE FEDERAL CERTIFICATION LABEL CONTAINS THE INCORRECT TIRE PRESSURE INFLATION INFORMATION. THIS DOES NOT COMPLY WITH REQUIREMENTS OF PART 567, "CERTIFICATION" AND FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

What can happen. UNDER OR OVER-INFLATED TIRES CAN CAUSE OR CONTRIBUTE TO PREMATURE TIRE FAILURE, POSSIBLY RESULTING IN A SUDDEN BLOWOUT OR OTHER FAILURE WHICH COULD RESULT IN A LOSS OF CONTROL OF THE VEHICLE.

The fix. DEALERS WILL REPLACE THE CERTIFICATION LABEL WITH A NEW LABEL, WHICH CONTAINS THE CORRECT RECOMMENDED TIRE INFLATION DATA.

Campaign 00V331000. See it on NHTSA

Holiday Rambler does not have manuals online that we could find. The makers of the fridge, water heater, furnace and slides do, and they cover most of the rig. Our free manuals on this page explain how each system works.

Yes. NHTSA lists 32 recalls for it. The most common area is service brakes. Check your own VIN on the NHTSA site to see if yours was fixed.

Yes. A safety recall is fixed free by the maker's dealers no matter who owns the rig now or how old it is. Call the maker or any dealer for that brand with your VIN.

Look for a sticker by the entry door, inside a cabinet near the door, or on the tongue or front frame of a trailer. The title and registration show it too.