Tiffin Allegro Manual

What is wrong. Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2022-2023 Allegro Bay, Breeze, Phaeton, Red 360, 2023 Allegro and Red 340 motorhomes. The fitting on the non-leaching hose connected to the LPG regulator may leak at the swivel joint.

What can happen. A fuel leak in the presence of an ignition source increases the risk of a fire.

The fix. Dealers will inspect and replace the LPG hose, as necessary, free of charge. Owner notification letters were mailed November 11, 2022. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-127.

Campaign 22V814000. See it on NHTSA

How this part works is in our propane, furnace and fridge manual.

What is wrong. Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2021-2023 Allegro, Red 340, 2021-2022 Phaeton, Breeze, Allegro Red 360, and 2022 Bay motorhomes. The output line on the LPG tanks may not connect properly to the service valve, which can cause a propane leak.

What can happen. A propane leak in the presence of an ignition source can increase the risk of a fire.

The fix. Dealers will inspect and replace the service valves, as necessary, free of charge. Owner notification letters were mailed September 18, 2022. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-124.

Campaign 22V511000. See it on NHTSA

How this part works is in our propane, furnace and fridge manual.

What is wrong. Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2021-2022 Allegro and 2022 Allegro Bay motorhomes. The slide-room may extend out 6 to 8 inches while parked or possibly while moving, due to defective seals in the hydraulic cylinders.

What can happen. A slide-room that were to extend unintentionally during transit can increase the risk of a crash.

The fix. Dealers will replace the hydraulic cylinders, as necessary, free of charge. Owner notification letters were mailed June 1, 2022. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-122.

Campaign 22V273000. See it on NHTSA

What is wrong. Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2018-2022 Allegro and Allegro Breeze motorhomes. The buss bar may be improperly secured, which can cause electrical components in the DC Distribution Panel to overheat.

What can happen. Overheated electrical components can melt and increase the risk of a fire.

The fix. Dealers will replace the buss bar with a cable, free of charge. Owner notification letters were mailed March 18, 2022. Owners may contact Tiffin customer service at 1-256-356-0261. Tiffin's number for this recall is TIF-120.

Campaign 22V068000. See it on NHTSA

How this part works is in our shore power and batteries manual.

What is wrong. Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2018-2022 Allegro Breeze, Allegro Red, Allegro, Allegro Bus, Phaeton, and 2018-2021 Zephyr recreational vehicles. The sofa seat belts may not have been installed correctly, which could result in unsecured passengers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."

What can happen. Unsecured passengers have an increased risk of injury in the event of a crash.

The fix. Dealers will inspect and repair the seat belts as necessary, free of charge. Owner notification letters were mailed October 29, 2021. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-118.

Campaign 21V680000. See it on NHTSA

What is wrong. Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2021-2022 Allegro Bus and Phaeton motorhomes, equipped with certain Cummins L9 diesel engines. A fuel leak may occur from the fuel hose between the fuel pump and remote filter head.

What can happen. A fuel leak in the presence of an ignition source can increase the risk of a fire.

The fix. Dealers will replace the fuel hoses, free of charge. Owner notification letters were mailed September 10, 2021. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-117.

Campaign 21V545000. See it on NHTSA

What is wrong. Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2009-2018 Allegro and Allegro RED, Bus and Phaeton vehicles, 2009-2010 Bay vehicles, 2011-2018 Breeze vehicles, and 2009-2015, and 2017-2018 Zephyr vehicles. These motorhomes are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

What can happen. In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

The fix. Tiffin will notify owners, and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on February 5, 2018. Owners may contact Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Owners may also contact Tiffin customer service at 1-256-356-8661.

Campaign 17V841000. See it on NHTSA

What is wrong. Tiffin Motorhomes, Inc. (Tiffin) is recalling certain model year 2015-2017 Allegro Open Road motorhomes manufactured April 1, 2015, to September 16, 2016. The affected vehicles have a tow hitch with a weight capacity sticker that may indicate an incorrect weight capacity.

What can happen. If the hitch is loaded to the weight on sticker, the hitch may fail and the towed vehicle can separate from the motorhome, increasing the risk of a crash.

The fix. Tiffin will notify owners, and send them a corrected label to replace the incorrect label, free of charge. The recall began on October 31, 2016. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-104.

Campaign 16V692000. See it on NHTSA

What is wrong. Tiffin Motorhomes (Tiffin) is recalling certain model year 2017 Allegro Open Roads vehicles manufactured June 7, 2016, to August 15, 2016. The affected vehicles have a driver-side wiper arm that may sweep off of the edge of the windshield, when trying to return, the wiper arm may break.

What can happen. A broken windshield wiper may reduce the driver's visibility, increasing the risk of a crash.

The fix. Tiffin will notify owners, and dealers will replace the driver-side wiper pivot shaft and extending linkage, free of charge. The recall began on September 12, 2016. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-102.

Campaign 16V623000. See it on NHTSA

What is wrong. Tiffin Motorhomes, Inc. (Tiffin) is recalling certain model year 2007-2011 Allegro, Allegro Bus, Phaeton, and Zephyr motorhomes, 2007-2010 Allegro Bay motorhomes, and 2010-2011 Allegro Breeze motorhomes. The windshield wiper arms on the affected vehicles may break off.

What can happen. If the windshield wiper arms break, the driver's visibility may be reduced, increasing the risk of a crash.

The fix. Tiffin will notify owners, and dealers will replace the wiper blade arms, free of charge. The recall began on August 19, 2016. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIFF-100.

Campaign 16V532000. See it on NHTSA

What is wrong. Tiffin Motorhomes is recalling certain model year 2014-2016 Allegro Phaeton and 2015-2016 Allegro Bus trucks manufactured October 1, 2014 to August 1, 2015, equipped with certain ZF RL77 / 80EM independent front steering axles equipped with Bosch 8018 steering boxes. The boxes were manufactured using incorrect internal spacers that can cause premature wear in the connection between the steering wheel and the front axle.

What can happen. The steering wheel's connection to the front axle could fail resulting in a sudden loss of steering ability, increasing the risk of a crash.

The fix. Tiffin will notify owners, and dealers will inspect and replace the steering box if necessary, free of charge. Owners are urged not to drive their vehicles until they have been inspected. The recall began on August 17, 2016. Owners may contact Tiffin customer service at 1-256-356-8661.

Campaign 16V397000. See it on NHTSA

What is wrong. Tiffin Motorhomes (Tiffin) is recalling certain model year 2007-2015 motorhomes manufactured May 1, 2007, to December 31, 2014, equipped with certain Coachstep Double and Triple Electric Steps. The bolt that attaches the fan gear assembly to the steps may fracture allowing the fan gear to disengage from the steps. As a result, the steps may not remain in the expected position and may become unstable.

What can happen. Unstable entry and exit steps increase the risk of injury.

The fix. Dealers will install a retainer bracket on the double step assemblies and the Coachstep Linkage Assembly will be replaced and a retainer bracket will be installed on the trip step assemblies. The recall began on Ferbuary 10, 2016. Owners may contact Tiffin customer service at 1-256-356-8661, or Lippert customer service at 1-574-537-8900.

Campaign 15V880000. See it on NHTSA

What is wrong. Tiffin Motorhomes, Inc.(Tiffin) is recalling certain model year 2015 Allegro Red 36 QSA, Allegro Red 38 QBA, Phaeton 40 QBH, and Phaeton 40 QKH motorhomes manufactured April 22, 2014, to May 8, 2015. In the affected vehicles, moisture may enter the slide-out controller and cause the "switch out" connection to short, and cause the motorhome slide-out section to extend while the motorhome is moving.

What can happen. If the slide-out opens during transit, there is an increased risk of a vehicle crash.

The fix. Tiffin will notify owners, and dealers will install a relay to disconnect the power source of the slide-out, free of charge. The recall began on June 16, 2015. Owners may contact Tiffin customer service at 1-256-356-8661.

Campaign 15V297000. See it on NHTSA

What is wrong. Tiffin Motorhomes, Inc. (Tiffin) is recalling certain model year 2009-2011 Allegro, 2010-2011 Bus and Breeze, and 2008-2011 Phaeton and Zephyr recreational vehicles, equipped with LED clearance lights made by Command Electronics, Inc. In the affected vehicles, moisture may enter the light and cause a short between two connections on the circuit board.

What can happen. A short in the circuit board increases the risk of a fire.

The fix. Tiffin will notify owners, and dealers will install a one amp inline fuse into the front and rear circuits that will blow if there is a short in any of the clearance lights, free of charge. The recall began on July 31, 2014. Owners may contact Tiffin customer service at 1-256-356-8661.

Campaign 14V271000. See it on NHTSA

How this part works is in our shore power and batteries manual.

What is wrong. Villa International (Villa) is recalling certain Villa ISS driver and passenger GSK seats. These seats were used in certain model year 2014 Tiffin Allegro Bus and Zephyr recreational vehicles, 2015 American Coach brand American Eagle, American Tradition, and American Revolution recreational vehicles, and 2014 Jayco Entegra Cornerstone recreational vehicles. The seat belt attachment may be incorrect and the seat belt may fray if it rubs along a steel bracket in the seat, reducing its strength. As such, these seats do not conform to Federal Motor Vehicle Safety Standard (FMVSS) number 209, "Seat Belt Assemblies."

What can happen. The weakened seat belt may fail to properly restrain the seat occupant in the event of a crash, increasing the risk of injury.

The fix. Villa will notify the affected vehicle manufacturers and the manufacturer's dealers will contact the vehicle owners. Owners may contact Villa at 1-888-707-7272.

Campaign 14E015000. See it on NHTSA

What is wrong. Tiffin Motorhomes, Inc. (Tiffin) is recalling certain model year 2013-2014 Allegro 33AA motorhomes equipped with an electric fireplace. In the affected vehicles, the fireplace may ignite a piece of exposed wood inside the electric fireplace.

What can happen. If the exposed piece of wood ignites, the rest of the motorhome could also catch fire.

The fix. Tiffin will notify owners, and dealers will install a heat shield to keep heat from the exposed wood, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Tiffin at 1-256-356-8661.

Campaign 13V638000. See it on NHTSA

What is wrong. Tiffin Motorhomes, Inc. (Tiffin) is recalling certain model year 2013 Breeze and Allegro motorhomes. If the awning installation sequence was not completely followed, the awning motor may unknowingly become damaged.

What can happen. If motor damage has occurred, it is possible that the awning can unfurl unexpectedly, either while the motorhome is at rest or while in transit, increasing the risk of personal injury or a vehicle crash.

The fix. Tiffin will notify owners and Dometic staff will replace the affected motors with a design that is not subject to an out-of-sequence installation error. The recall began June 24, 2013. Owners may contact Tiffin at 1-256-356-8661 or Dometic at 1-888-447-0003 for more information. Owners are being instructed not to drive their vehicle until repairs can be performed.

Campaign 13V178000. See it on NHTSA

What is wrong. TIFFIN IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2010 ALLEGRO AND ALLEGRO BAY RECREATIONAL VEHICLES EQUIPPED WITH BOSCH HYDRAULIC BRAKES. HYDRAULIC BRAKE EQUIPPED MOTORHOME CHASSIS EXPOSED TO LONG PERIODS OF TIME OF NON-DRIVING MAY EXPERIENCE DIAMETRICAL BRAKE CALIPER PISTON GROWTH AND REDUCED PISTON TO BORE CLEARANCE POTENTIALLY LEADING TO BRAKE DRAG AND OVERHEATING RESULTING IN REDUCED BRAKE PERFORMANCE.

What can happen. REDUCED BRAKE PERFORMANCE MAY LEAD TO AN INCREASED RISK OF A CRASH.

The fix. TIFFIN WILL NOTIFY THE OWNERS, AND AUTHORIZED DAIMLER TRUCKS NORTH AMERICA (DTNA) DEALERS WILL INSPECT AND, AS NECESSARY, REPLACE THE BRAKE CALIPERS FREE OF CHARGE. AN INTERIM NOTICE WAS MAILED TO OWNERS BY DTNA ON AUGUST 6, 2012. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

Campaign 12V327000. See it on NHTSA

What is wrong. TIFFIN IS RECALLING CERTAIN MODEL YEAR 2010 THROUGH 2012 ALLEGRO MOTORHOMES BUILT ON FORD F-53 AND F-59 STRIPPED CHASSIS. THE GEAR SHIFT CABLE MAY BREAK AT THE ATTACHMENT TO THE TRANSMISSION CONTROL SELECTOR ARM ASSEMBLY MOUNTED ON THE STEERING COLUMN. IF THE CABLE BREAKS, THE TRANSMISSION GEAR INDICATOR IN THE GEAR SHIFT DISPLAY IN THE INSTRUMENT PANEL WILL REMAIN IN THE FIRST GEAR POSITION REGARDLESS OF THE GEAR SELECTED. 

What can happen. AN INCORRECT GEAR INDICATION IN THE INSTRUMENT PANEL MAY PREVENT THE DRIVER FROM KNOWING IF THEY ARE IN PARK OR REVERSE, INCREASING THE RISK OF A CRASH.

The fix. TIFFIN IS WORKING WITH FORD TO IDENTIFY AND NOTIFY OWNERS OF THE AFFECTED MOTORHOMES. FORD WILL REPLACE THE TRANSMISSION SELECTOR ARM ASSEMBLY AND THE GEAR SHIFT CABLE ASSEMBLY, FREE OF CHARGE. OWNERS MAY CONTACT TIFFIN AT 1-256-356-8661 OR FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

Campaign 12V215000. See it on NHTSA

What is wrong. TIFFIN MOTORHOMES, INC. (TIFFIN) IS RECALLING CERTAIN MODEL YEAR 2011 ALLEGRO AND PHAETON RECREATIONAL VEHICLES BUILT ON FREIGHTLINER CHASSIS AND EQUIPPED WITH A CUMMINS ISC, ISX, ISM, OR ISL DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.

What can happen. IF THE INLET OR OUTLET SECTIONS DISCONNECT, HOT EXHAUST GASES CAN VENT PRIOR TO EXITING THE TAILPIPE, CREATING THE RISK OF COMBUSTION AND A FIRE. IF BOTH CLAMPS FAIL, THERE IS A RISK IN SOME APPLICATIONS THAT THE DOC/DPF HOUSING MAY DETACH COMPLETELY, CREATING A ROAD HAZARD.

The fix. TIFFIN IS WORKING WITH CUMMINS TO IDENTIFY AND NOTIFY OWNERS OF THE RECALL CAMPAIGN. REPAIRS WILL BE PERFORMED BY AUTHORIZED CUMMINS DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 10, 2011. OWNERS MAY CONTACT CUMMINS AT 1-812-377-5000 OR TIFFIN AT 1-256-356-8661.

Campaign 11V547000. See it on NHTSA

What is wrong. TIFFIN MOTORHOMES IS RECALLING CERTAIN MODEL YEAR 2007-2011 PHAETON, MY 2008-2010 BUS, AND MY 2010 ALLEGRO MOTORHOMES EQUIPPED WITH KONGSBERG AUTOMOTIVE ADJUSTABLE BRAKE PEDALS. THE ADJUSTABLE BRAKE PEDAL ARM MAY LOOSEN ALLOWING THE ARM TO ROTATE AROUND ITS SHAFT AND SWING IN FRONT OF THE ACCELERATOR PEDAL, REDUCING BRAKING FUNCTION.

What can happen. A LOOSE BRAKE PEDAL INCREASES THE RISK OF A CRASH.

The fix. DAMILER TRUCKS (DTNA) IS PERFORMING RECALL REPAIRS AND NOTIFICATION TO OWNERS. THE OWNERS WERE INITIALLY NOTIFIED BY DTNA TRUCKS ON DECEMBER 22, 2009, AND A FOLLOW UP NOTICE WAS MAILED TO OWNERS ON JULY 20, 2011. OWNERS MAY CONTACT DTNA WARRANTY CLAIMS DEPARTMENT AT 1-800-547-0712 OR TIFFIN MOTORHOMES AT 1-256-356-8661 FOR MORE INFORMATION.

Campaign 11V452000. See it on NHTSA

What is wrong. TIFFIN MOTORHOMES IS RECALLING CERTAIN MODEL YEAR 2006-2010, ALLEGRO AND ALLEGRO BAY RECREATIONAL VEHICLES, MANUFACTURED FROM JANUARY 2005, THROUGH APRIL 2010, AND BUILT ON A DAIMLER/FREIGHTLINER CHASSIS. THE BRAKE LIGHTS MAY BE INTERMITTENT DURING LIGHT BRAKE APPLICATIONS.

What can happen. THE BRAKE LIGHTS MAY NOT ILLUMINATE CONSISTENTLY UPON BRAKE APPLICATION AND FAIL TO PROPERLY INDICATE TO A FOLLOWING VEHICLE THAT THE MOTORHOME HAS SLOWED OR COME TO A STOP, INCREASING THE RISK OF A CRASH.

The fix. DAIMLER TRUCKS (DTNA), MANUFACTURER OF THE CHASSIS, WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY DTNA DEALERSHIPS, FREE OF CHARGE. (SEE DTNA'S RECALL CAMPAIGN 10V-178.) THE SAFETY RECALL BEGAN ON MAY 27, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

Campaign 11V327000. See it on NHTSA

What is wrong. TIFFIN MOTORHOMES IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

What can happen. THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

The fix. TIFFIN MOTORHOMES IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE SAFETY RECALL BEGAN ON FEBRUARY 17, 2011. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101.

Campaign 11V082000. See it on NHTSA

What is wrong. TIFFIN IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

What can happen. THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

The fix. TIFFIN IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN ON FEBRUARY 17, 2011. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR TIFFIN AT 1-256-356-8661.

Campaign 10V585000. See it on NHTSA

What is wrong. TIFFIN MOTORHOMES IS RECALLING CERTAIN MODEL YEAR 2011 ALLEGRO, ALLEGRO BUS, AND PHAETON RVS EQUIPPED WITH ATWOOD 35 SERIES RANGE OVENS. A POTENTIAL EXISTS FOR A SMALL FRACTURE WITHIN THE LINE DELIVERING GAS TO THE OVEN CAVITY BURNER. SUCH A FRACTURE MAY CAUSE PROPANE GAS TO LEAK FROM THE LINE.

What can happen. A PROPANE LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE AND/OR EXPLOSION CAUSING PROPERTY DAMAGE AND/OR PERSONAL INJURY.

The fix. TIFFIN IS WORKING WITH ATWOOD AND WILL REPLACE OR REPAIR THE STOVES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 28, 2010. OWNERS MAY CONTACT ATWOOD AT 1-574-266-4749 OR TIFFIN 1-256-356-8661.

Campaign 10V512000. See it on NHTSA

What is wrong. TIFFIN IS RECALLING CERTAIN RECREATIONAL VEHICLE EQUIPPED WITH NORCOLD MODEL 1200LR AND 1200LRIM REFRIGERATORS, MANUFACTURED FROM DECEMBER 1, 2001, WITH SERIAL NUMBERS BETWEEN 1273701 AND 1536607, NON-CONSECUTIVELY. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK. IF A LEAK OCCURS AND THE REFRIGERATOR CONTINUES TO BE OPERATED AFTER SOLUTION CIRCULATION HAS CEASED THE HEAT SOURCE COULD GENERATE VERY HIGH TEMPERATURES. AT SUCH HIGH TEMPERATURES, THE COOLING UNIT COULD RUPTURE.

What can happen. IF A LEAK OCCURS AND THE UNIT IS CONTINUES TO OPERATE, HYDROGEN GAS MAY BE EXPELLED AND CAN BE IGNITED, RESULTING IN A FIRE, POSSIBLY CAUSING SERIOUS INJURY OR DEATH.

The fix. TIFFIN IS WORKING WITH NORCOLD AND TIFFIN WILL NOTIFY OWNERS AND THE VEHICLE'S REFRIGERATOR WILL BE REPAIRED FREE OF CHARGE BY NORCOLD. PLEASE SEE NORCOLD'S DEFECT REPORT 09E-027. OWNERS MAY CONTACT NORCOLD'S RECALL CENTER AT 1-800-767-9101.

Campaign 09V443000. See it on NHTSA

What is wrong. NAVISTAR IS RECALLING CERTAIN MODEL YEAR MY 2001-2008 WORKHORSE W20, W21 AND W22 CHASSIS AND CERTAIN MODEL YEAR 2009 THROUGH 2011 MONACO RV ADMIRAL, ARISTA, MONARCH, AND RIPTIDE RECREATIONAL VEHICLES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.

What can happen. THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.

The fix. WORKHORSE DEALERS WILL REPLACE ALL FOUR BOSCH BRAKE CALIPER ASSEMBLIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2010. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731.

Campaign 09V110000. See it on NHTSA

What is wrong. TIFFIN IS RECALLING 3,507 MY 2004-2007 ALLEGRO, ALLEGRO BAY AND ALLERO BUS, MY 2004-2005 PHAETON AND MY 2005-2007 ZEPHYR MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

What can happen. RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

The fix. TIFFIN WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR TIFFIN AT 256-356-8661.

Campaign 08V509000. See it on NHTSA

What is wrong. TIFFIN IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH NORCOLD REFRIGERATORS. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.

What can happen. EXTENDED OPERATION OF A LEAKING COOLING UNIT COULD LEAD TO A FIRE FROM GAS WHICH MIGHT ESCAPE.

The fix. TIFFIN IS WORKING WITH NORCOLD TO REPAIR THESE REFRIGERATORS. NORCOLD WILL PROVIDE THERMAL SWITCH KITS TO OWNERS ALONG WITH THE NECESSARY FORMS AND INSTRUCTIONS. THE RECALL IS EXPECTED TO BEGIN DURING OCTOBER 2008. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR TIFFIN AT 1-256-356-8661.

Campaign 08V433000. See it on NHTSA

What is wrong. ON CERTAIN MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION, THESE REFRIGERATORS MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

What can happen. RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

The fix. TIFFIN MOTORHOMES WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR TIFFIN AT 1-256-356-8661.

Campaign 07V517000. See it on NHTSA

What is wrong. ON CERTAIN MOTOR HOMES, THE TV IS NOT SECURED SUFFICIENTLY AND COULD FALL OUT WHEN THE MOTORHOME IS MOVING.

What can happen. THE TV COULD SLIDE OUT WHEN UNIT IS IN MOTION INCREASING THE RISK OF PERSONAL INJURY TO VEHICLE OCCUPANTS.

The fix. DEALERS WILL SCREW THE TV INTO THE CABINET SECURELY FREE OF CHARGE. TIFFIN CALLED OWNERS TO MAKE ARRANGEMENTS TO HAVE THE REPAIRS PERFORMED. THE RECALL BEGAN ON APRIL 2, 2007. OWNERS MAY CONTACT TIFFIN AT 256-356-8661.

Campaign 07V160000. See it on NHTSA

What is wrong. CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH ACTIA CORPORATE INSTRUMENT CLUSTERS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101, CONTROLS AND DISPLAYS, AND NO. 105, HYDRAULIC AND ELECTRIC BRAKE SYSTEMS. IF THE BRAKE FAIL INPUT FALLS BELOW A VOLTAGE OF 1.5V, THE BRAKE FAILURE LAMP AND ALARM WILL BE ACTIVATED. ALSO ACTIVATION OF THE ABS TELLTALE WHEN THE ABS IS NOT PROPERLY FUNCTIONING DOES NOT ALWAYS OCCUR.

What can happen. AT NIGHT THE INSTRUMENT CLUSTER LIGHTS MAY FAIL AND THE DRIVER MAY NOT BE ABLE TO SEE THE INSTRUMENT PANEL GAUGES AND THE BRAKE WARNING LIGHT INDICATOR WHICH COULD INCREASING THE RISK OF A CRASH.

The fix. TIFFIN IS WORKING WITH WORKHORSE TO CONTACT THE OWNERS AND REMEDY THIS CAMPAIGN . WORKHORSE WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731 OR TIFFIN AT 1-256-356-0205.

Campaign 06V142000. See it on NHTSA

How this part works is in our shore power and batteries manual.

What is wrong. ON CERTAIN MOTOR HOMES CONTAINING A 50 AMP TRANSFER SWITCH BUILT BY INTELLITEC, THE MATERIAL USED FOR THE WIRE LUGS WAS CHANGED FROM NICKEL PLATED TO COPPER LUGS. THE COPPER LUGS ARE SOFTER THAN THE NICKEL PLATED AND DO NOT RETAIN THE TORQUE OF THE SCREW THAT CLAMPS THE WIRE CONNECTOR.

What can happen. WHEN THE TORQUE IS RELAXED, THE LUGS CAN BECOME LOOSE RESULTING IN EXCESSIVE HEAT WITHIN THE CONNECTED WIRE THAT COULD RESULT IN A FIRE.

The fix. DEALERS WILL REPLACE THE CHANGEOVER BOX. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT TIFFIN AT 1-256-356-8661.

Campaign 05V307000. See it on NHTSA

How this part works is in our shore power and batteries manual.

What is wrong. THE SEAT BELT ASSEMBLIES ON CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE LOOP LOAD REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209. "SEAT BELT ASSEMBLIES."

What can happen. THE SEAT BELT BUCKLE MAY UNLATCH IN THE EVENT OF A VEHICLE CRASH, POSSIBLY RESULTING IN PERSONAL INJURY TO THE SEAT OCCUPANT.

The fix. AMSAFE WILL REPLACE THE BUCKLES. OWNERS SHOULD CONTACT AMSAFE AT 574-266-8330 OR TIFFIN AT 1-256-356-8661.

Campaign 04V383000. See it on NHTSA

What is wrong. CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.

What can happen. IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE BRAKE SYSTEM WARNING INDICATOR.

The fix. DEALERS WILL REPAIR THE BRAKE WARNING LAMP CIRCUIT. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TIFFIN AT 1-256-356-8661.

Campaign 03V149000. See it on NHTSA

What is wrong. VEHICLE DESCRIPTION: MOTOR HOMES EQUIPPED WITH SAFETY BELT ASSEMBLIES PRODUCED BY AM-SAFE. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.

What can happen. SERIOUS INJURY OR DEATH COULD OCCUR IF THE VEHICLE OCCUPANT IS NOT PROPERLY RESTRAINED.

The fix. AM-SAFE NOTIFIED TIFFIN'S CUSTOMERS TO RETURN THEIR VEHICLE TO AN AUTHORIZED DEALER TO HAVE THE SEAT BELTS REPAIRED FREE OF CHARGE. OWNER NOTIFICATION BEGAN AUGUST 31, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AM-SAFE COMMERCIAL PRODUCTS AT 219-266-8330.

Campaign 01V097008. See it on NHTSA

Tiffin does not have manuals online that we could find. The makers of the fridge, water heater, furnace and slides do, and they cover most of the rig. Our free manuals on this page explain how each system works.

Yes. NHTSA lists 36 recalls for it. The most common area is service brakes. Check your own VIN on the NHTSA site to see if yours was fixed.

Yes. A safety recall is fixed free by the maker's dealers no matter who owns the rig now or how old it is. Call the maker or any dealer for that brand with your VIN.

Look for a sticker by the entry door, inside a cabinet near the door, or on the tongue or front frame of a trailer. The title and registration show it too.